Product ID:HEAVY DUTY DEGREASER AEROSOL
MSDS Date:03/04/1993
FSC:6850
NIIN:01-244-9614
MSDS Number: BVZKP

C R C CHEMICALS U.S.A.

885 LOUIS DRIVE
WARMINSTER, PA 18974-2820
US

Emergency Phone: 215-674-4300

Info Phone: 215-674-4300

Cage: IO004

CRC INDUSTRIES, INC.

WARMINSTER, PA 18974-2820 US

Telephone: 215-674-4300/800-424-9300

Cage: 10136

METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)

CAS: 71-55-6

RTECS: KJ2975000

Fraction By Weight: 91% %

OSHA PEL 350 PPM

ACGIH TLV: 350 PPM/450STEL;9394

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SEC-BUTYL ALCOHOL (SARA III)

CAS: 78-92-2

RTECS: EO1750000

Fraction By Weight: 1.2% %

OSHA PEL 150 PPM

ACGIH TLV: 100 PPM; 9394

1,3-DIOXOLANE

CAS: 646-06-0

RTECS: JH6760000

Fraction By Weight: 2.75% %

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: 4% %

OSHA PEL 5000 PPM

ACGIH TLV: 5000PPM/30000STEL;94

1,2-EPOXYBUTANE (SARA III)

CAS: 106-88-7

RTECS: EK3675000

Fraction By Weight: < 1%

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION MAY CAUSE HEADACHES,
DIZZINESS, ANETHESIA, UNCONSCIOUSNESS. MAY CAUSE EYE PAIN AND SOME
IRRITATION. REPEATED CONTACT MAY CAUSE SKIN IRRITATION. REPEATED
OVEREXPOSURES HAVE CAUSED LIVER EFFE CTS IN EXPERIMENTAL ANIMALS.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:HEADACHES, DIZZINESS, ANETHESIA,
UNCONSCIOUSNESS, EYE PAIN, EYE IRRITATION, SKIN IRRITATION.
POSSIBLE LIVER EFFECTS.
Medical Cond Aggravated by Exposure:HIGH LEVELS (800 PPM+) OF VAPOR
MAY CAUSE CARDIAC ARRHYTHMIAS.

First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSISTS, GET MEDICAL
ATTENTION. IN HALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL
ATTENTION.

Flash Point Method:TCC
Flash Point:NONFLAMMABLE
Lower Limits:7.5 %
Upper Limits:12.5 %
Extinguishing Media:WATER FOG
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:AEROSOL CONTAINERS MAY EXPLOED WHEN
HEATED ABOVE 120F.

Spill Release Procedures:USUALLY NOT A PROBLEM WITH AEROSOLS. AREA
SHOULD BE VENTED AND ABSORBENT USED TO PICK UP EXCESS MATERIAL.
COLLECT FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:AVOID SKIN CONTACT. LAUNDER CONTAMINATED CLOTHING
BEFORE REUSE.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS PER
CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND NIOSH RESPIRATOR
SELECTION.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION TO
MAINTAIN EXPOSURE LEVELS.
Protective Gloves:SOLVENT RESISTANT
Eye Protection:SAFETY GLASSES OR GOGGLES
Other Protective Equipment:PROTECTIVE CLOTHING AS REQUIRED TO AVOID
SKIN CONTACT. AN EMERGENCY EYE WASH STATION AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER HANDLING PRODUCT
AND BEFORE EATING DRINKING OR SMOKING.
Supplemental Safety and Health
VAPORS ARE HEAVIER THAN AIR AND WILL COLLECT IN LOW AREAS. DO NOT USE
IN CONFINED AREAS OR LOW SPOTS WITHOUT ADEQUATE VENTILATION. IF
VAPORS ARE SUSPECTED IN A LOW AREA, DO NOT ENTER UNLESS SPECIAL BR
EATHING APPARATUS IS USED AND AN OBSERVER IS PRESENT FOR
ASSISTANCE.

HCC:V2
Boiling Pt:=73.9C, 165.F
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:100
Vapor Density:4.55
Spec Gravity:1.305
Evaporation Rate & Reference:RAPID
Solubility in Water:SLIGHT
Appearance and Odor:COLORLESS LIQUID, IRRITATING ODOR AT HIGH
CONCENTRATIONS
Percent Volatiles by Volume:100 %

Stability Indicator/Materials to Avoid:YES
AVOID STORAGE IN ALUMINUM CONTAINERS OR CONTACT WITH ALUMINUM POWDER OR
ZINC POWDER.
Stability Condition to Avoid:HEAT, OPEN FLAME, ARCS, SPARKS
Hazardous Decomposition Products:HYDROGEN CHLORIDE, CHLORINE AND SOME
PHOSGENE.

Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.